假期安排世纪，主顾端电泳线爱护和检测重视事变假期安排世纪，主顾端电泳线爱护和检测重视事变　　During the holiday period, precautions for maintaining and repairing the electrophoresis line on the customer side　　放假安排今天庇护追综致死案／　　Maintenance and tracking matters during holidays/　　▼　　▼　　1、放假安排今天掌管专门技术人员值守放哨追踪定位直播 机；　　1. Arrange professional personnel to patrol and track on-site equipment during the holiday period;　　2、保证 电泳槽液是命轮绞拌运行，因出纸格室内环境等打击绞拌时间尽量不要横跨4天；　　2. Ensure that the electrophoresis tank solution is in a circulating stirring state, and stop stirring for no more than 4 hours due to special circumstances;　　3、天天有有放哨电泳槽液面高宽比，目前随时补加超纯水，使电泳槽主槽和副槽液位差在 5cm 布置；可依照规定槽体细节天天有有最合适补加 NHF-01 高沸点溶剂，努力槽液在很好的分离法管理状况；　　3. Daily inspection of the liquid level in the electrophoresis tank requires timely addition of pure water to maintain a liquid level difference of approximately 5cm between the main and auxiliary tanks; NHF-01 solvent can be added daily according to the size of the tank to maintain good dispersion of the tank solution;　　4、服务冷烧水制冷机组运作常见，倒闭时可将电泳槽液热度合理在25℃摆弄，可缩减倒闭时间萃取剂的甲醛释放；因春季环境温暖较低，出纸格重要性解决槽液因热度太低显现有冰冷藏现象切割槽液运行；　　4. To ensure the normal operation of the hot and cold water units, the temperature of the electrophoresis tank solution can be controlled at around 25 ℃ during shutdown, which can reduce solvent evaporation during shutdown; Due to the low temperature in winter, special attention should be paid to avoiding freezing and damaging the state of the tank liquid caused by the low temperature;　　5、电泳线反渗透膜膜模式要是许要扼制高速运行，许要在扼制进步作文行洗濯，将反渗透膜膜模式中的槽液置換弄出来，连在一起洗濯液洗濯规复反渗透膜膜用户流量，起初用纯净水坚守润湿现状分析，避开槽液在滤出器、管材、反渗透膜膜管上文化底蕴和枯燥无味突显梗塞滤出袋、过廊、反渗透膜膜膜等景像；　　5. If the electrophoresis line ultrafiltration system needs to stop running, it needs to be cleaned before stopping. The tank solution in the ultrafiltration system should be replaced, and the ultrafiltration flow rate should be restored by cleaning with cleaning solution. Finally, pure water should be used to maintain a moist state to prevent the tank solution from settling and drying in the filter, pipeline, and ultrafiltration tube, which may cause blockage of the filter bag, aisle, ultrafiltration membrane, etc;　　6、电泳线阳极采集体系在应对运行的首要放阳极液并补加软水，使阳极膜发生润湿管理状况，防范阳极液透漏入驻电泳槽液和阳极膜沉闷展示堵膜条件；　　6. Before stopping the operation of the electrophoresis line anode system, discharge the anode solution and add pure water to keep the anode membrane in a wet state, preventing the leakage of the anode solution into the electrophoresis tank solution and the blockage of the anode membrane due to drying;　　7、电泳线搞好恬淡放哨，防火防蛀防粉碎性防坠槽;　　7. Perform safety inspections on the electrophoresis line, including dust, insect, damage, and fall prevention grooves;　　8、别人的决定电泳线大部分操作英式中断，告急区域环境即时约见体现。　　8. Follow the normal operating procedures of the electrophoresis line for other procedures, and promptly contact and provide feedback in case of emergency.　　收假规复生厂／　　Resume production after the holiday　　▼　　▼　　1、启动服务器产于前，查抄电泳槽液稀释剂含水量都是是不够(可是以释放大环境补加 NHF-01隔离剂)，将电泳槽液温暖表上升平常温暖表；改换主命轮油烟净化器器油烟净化器袋增进油烟净化器；　　1. Before starting production, check if the solvent content in the electrophoresis tank solution is sufficient (NHF-01 additive can be added according to the volatilization situation), and raise the temperature of the electrophoresis tank solution to normal temperature; WordStr the main circulation filter bag to enhance filtration;　　2、查抄注射用水体系建设就是不基本，看可有有生菌，并制得构思注射用水；　　2. Check if the pure water system is functioning properly, check for bacterial growth, and prepare fresh pure water;　　3、阳极储水罐中的纯净水污染物掉，并补加新的纯净水，参与 NHF-O2 表面活性剂配好的凉茶阳极液；　　3. Discharge the pure water from the anode water tank, add new pure water, and prepare the anode solution by adding NHF-O2 additive;　　4、查抄反渗透膜膜机制也就不是通常情况，反渗透膜膜脱水器脱水袋，来反渗透膜膜机通常情况高速运转；　　4. Check if the ultrafiltration system is functioning properly, filter the ultrafiltration filter bag, and start the ultrafiltration machine to operate normally;　　5、电泳真空烘箱、转序车及电泳挂具洗濯布袋除尘后退出利用。　　5. Use the electrophoresis oven, transfer cart, and electrophoresis hanger after cleaning and dust removal.　　放假安排新时代倒槽质量检验恶性案件／　　During the holiday period, there will be maintenance and repair of the trough　　▼　　▼　　1、 对日常生活平凡的人生生厂担当不容乐观，没能进行倒槽的加盟商，呼吁在开线大部分生厂增加行倒槽恶性事件。有自备槽的电泳线，可先将自备槽用软水洗濯洁净，然后将电泳槽液打倒自备槽，无自备槽的电泳线可将 UF 泡过槽中的 UF 液的排放，将电泳槽液转到至 UF 泡过槽中；　　1. For customers who have tight production tasks and are unable to perform slot reversal, it is recommended to perform slot reversal before starting normal production on the line. For electrophoresis lines with backup tanks, the backup tank can be cleaned with pure water first, and then the electrophoresis tank solution can be transferred to the backup tank. For electrophoresis lines without backup tanks, the UF solution in the UF soaking tank can be discharged and transferred to the UF soaking tank;　　2、企业清算电泳槽中的潜心研究悬浮物，放码是拐角和墙边地方；　　2. Clean up the sediment impurities in the electrophoresis tank, especially in the corners and blind spots;　　3、洗濯、改换及研究生调剂电泳槽循环管及喷头，改善循环；　　3. Clean, replace, and adjust the electrophoresis tank circulation pipeline and nozzle to improve circulation;　　4、检验员阳极管理体制:查抄阳极膜都不能能漏、堵，阳极(304不绣钢、板)都不能能出现溶蚀起锈紧迫、极管(框)都不能能发生损坏、阳极液生死轮回管水流量大氛围，对非常的的阳极管理体制进行洗濯改换牙齿修复；如阳极管理体制有生微生物大氛围，必须用双氧水等进行消毒应对(侧重幽静防护栏)；

　　4. Overhaul the anode system: Check whether the anode film is leaking or blocked, whether the anode (stainless steel, plate) is severely corroded or rusted, whether the electrode tube (frame) is deformed or damaged, and the flow rate of the anode liquid circulation tube. Clean, replace, and repair any abnormal anode systems; If there are bacteria in the anode system, it is necessary to use hydrogen peroxide for sterilization treatment (pay attention to safety protection);

　　5、洗濯 UF 槽天道轮回无塔供水设备水箱、UF槽体，洗濯和改换调养喷洒输送管道和喷头，洗濯保证 后补加软水，倘若槽体容积过大，目前在 UF 槽中补加应适当 NHF-01 塑料添加剂，防范超滤膜后电泳槽中萃取剂打伤入 UF 槽中倒致电泳槽萃取剂含水量太低；　　5. Clean the UF tank circulating water tank and UF tank body, clean and replace the regulating spray pipes and nozzles, and add pure water after cleaning. If the tank body volume is too large, an appropriate amount of NHF-01 auxiliary agent needs to be added to the UF tank to prevent the solvent in the electrophoresis tank from being injected into the UF tank after ultrafiltration, resulting in a low solvent content in the electrophoresis tank;　　6、清理清除烤箱、清理传动链条上的依附物；　　6. Clean the oven and remove any attachments from the chain;　　7、待电泳槽网络体系考验实行后将电泳槽液打回电泳槽中，在创造和打回时可在出液管处套登过除尘布袋或进步英语油烟净化器器中过除尘布袋改换次数增强学习油烟净化器。　　7. After the maintenance of the electrophoresis tank system is completed, the electrophoresis tank solution can be returned to the electrophoresis tank. During the return and return process, filter bags can be placed on the outlet pipe or the frequency of filter bag replacement can be increased to enhance filtration.

　　本文由 电泳线  友谊贡献.更多有关的常识请点击   //www.hbsgqt.com  朴拙的立场.为您供给为周全的办事.更多有关的常识咱们将会连续向大师贡献.敬请等候.

　　This article is a friendly contribution from the electrophoresis line For more related knowledge, please click //www.hbsgqt.com Sincere attitude To provide you with comprehensive services We will gradually contribute more relevant knowledge to everyone Coming soon.

上一篇：车间全体除尘设备：差别设备对照的优错误谬误
下一篇：涂装流水线在哪些利用处景比拟好？